Air Parking Heater Precautions
Danger!
Risk of injury, fire and poisoning!
• The heater must only be started up when the maintenance flap is closed and the outlet hood is mounted in position.
• The maintenance flap must not be opened during operation.
• Disconnect the vehicle battery before commencing any kind of work.
• Before working on the heater, switch the heater off and let all hot parts cool down.
• The heater must not be operated in closed rooms, e.g. in the garage or in a multi-storey car park.
• Adjustable hot air outlets must always be adjusted so that they cannot blow hot air directly at living creatures (people, animals) or objects sensitive to temperature (loose and / or fastened).
Caution!
Safety instructions for installation and operation!
• The year of initial commissioning must be marked on the nameplate.
• The heat exchanger of air heaters is a component subject to high thermal loads which must be replaced 10 years after initial commissioning of the heater. In addition, the installation date must be entered on the plate “original spare part” enclosedwith the heat exchanger must. Then affix the plate next to the nameplate on the heater.
• The heater must only be installed by a JE partner authorised by the manufacturer according to the instructions in this manual and possibly according to special installation recommendations; the same applies to any repairs to be carried out in the case or repairs or guarantee claims.
• The following measures are not allowed:
– Changes to components relevant to the heater.
– Nonconformities in installation or operation from the statutory regulations, safety instructions or specifications relevant to safe operation as stated in the installation instructions and operating instructions. This applies in particular to the electrical wiring, fuel supply, combustion air system and exhaust system.
• Only original accessories and original spare parts must be used during installation or repairs.
• When carrying out electric welding on the vehicle, the plus pole cable at the battery should be disconnected and placed at ground to protect the controller.
• The heater must not be operated where there is a risk of an accumulation of flammable vapours or dust, for example close to
– fuel depot
– coal depot
– wood depot
– grain depots etc.
• The heater must be switched off when refuelling.
• When the heater is mounted in a safety housing etc., the installation compartment of the heater is not a stowage compartment and must be kept clear. In particular fuel canisters, oil cans, spray cans, gas cartridges, fire extinguishers, cleaning rags, items of clothing, paper etc. must not be stored or transported on or next to the heater.
• Defect fuses must only be replaced by fuses with the prescribed rating.
• If fuel leaks from the heater fuel system, arrange for the damage to be repaired immediately by a JE service partner.
• After-running of the heater must not be interrupted prematurely e.g. by pressing the battery disconnecting switch, apart from in the case of an emergency stop.
Accident prevention
General accident prevention regulations and the corresponding workshop and operation safety instructions are to be observed.
